GMC Yukon 2000–2006

Manufacturer communication2003–2006 GMC YUKON ・ 2018-12-17

Headliner Sagging - Velcro Reattachment Preliminary Information

1. 1Fault

   • The headliner sags or does not stay tight to the roof or around the sunroof opening, if equipped.
   ↓→

2. 2Finding the cause

   • Headliner: loose or misadjusted

   Steps to confirm (in the document’s order)

   • On visual inspection, the hook and loop patch adhered to the roof, headliner or sunroof may be found detached.
   ↓→

3. 3Correction

   • Headliner: repaired

   Repair

   • Reattach the hook and loop patch using Hardman Double Bubble Epoxy part number 04001 or equivalent.

   Parts

   • Part 04001, Double Bubble Epoxy, quantity 1, to be obtained locally.

Recall2003 GMC YUKON ・ 2003-06-02

Side impact door hinge weld inspection recall

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   • Rear Door Hinge: design or manufacturing
   ↓→

3. 3Correction

   • Rear Door Upper Hinge: adjusted

Owner complaint2003 GMC YUKON ・ 2008-12-02

Rear heater not working

1. 1Fault

   • Air conditioning or heater
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   • Auxiliary Heater: replaced
   • Compressor: replaced
   • Interior Air Temperature Sensor: replaced

Recall2003 GMC YUKON ・ 2003-07-03

Running board courtesy lights overheat or fire risk recall

1. 1Fault

   • Overheating
   • Smoke or fire
   ↓→

2. 2Finding the cause

   • Wiring Harness: electrical fault
   ↓→

3. 3Correction

   • Wiring Harness: replaced

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-03-12(1 earlier editions of this document folded here)

Vehicle Lean Adjustment Preliminary Information

1. 1Fault

   • Lights (headlights, turn signals)
   • The procedure is for customer complaints of the vehicle leaning left or right.
   ↓→

2. 2Finding the cause

   Steps to confirm (in the document’s order)

   1. Measure the fender wheel-opening heights, front and rear, to quantify the lean.
   2. P height (front) and R height (rear) are the distance from the ground to the highest point of the wheel-opening, through the center of the wheel.
   3. Before measuring, set the tire pressures to the pressure shown on the certification label.
   4. Before measuring, check the fuel level and add weight if necessary to simulate a full tank.
   5. If the left-to-right difference in P and/or R height is 1/2 inch (12 mm) or less, the vehicle is within specification and no repair is suggested.
   ↓→

3. 3Correction

   Repair

   1. The vehicle's stance can generally be adjusted with the torsion bar adjuster bolts.
   2. If Z height is out of spec and the D height difference is greater than 1/2 inch (12 mm), adjust Z height until it is within spec and the P and R height differences are less than 1/2 inch (12 mm).
   3. If adjustment is not possible, check the front eye of the rear leaf springs for matching color-coded tape or paint: if the colors differ, switch the springs side to side; if they match, replace the leaf spring on the lower side only.
   4. After all adjustments, perform a front-end alignment and check headlight aim.

Manufacturer communication2000–2006 GMC YUKON ・ 2022-06-13(1 earlier editions of this document folded here)

Unusual Noise Diagnosis Technical Assistance

1. 1Fault

   • Noise
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   Repair

   • The noise can be recorded as audio or video with sound on a cell phone to send to TAC, or the PICOSCOPE can be used as a microphone.

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-04-16

TPO plastic fascias pre-painting/cleaning process

1. 1Fault

   • All fascias except those of the Corvette, Camaro and Cadillac XLR are made of TPO.
   ↓→

2. 2Finding the cause

   Steps to confirm (in the document’s order)

   • If unsure of the plastic type, look for the plastic symbol (TPO) on the back of the part.
   ↓→

3. 3Correction

   Repair

   1. Wash with soap and water, then clean with a 50% mix of isopropyl alcohol and water (or a waterborne cleaner).
   2. Scuff sand as the paint supplier recommends, then reclean with the 50% mix of isopropyl alcohol and water (or a waterborne cleaner).

   Caution

   • A solvent-type cleaner will soften or begin to dissolve the primer; base coats do not affect this primer.

Owner complaint2003 GMC YUKON ・ 2018-02-07

Rear tailgate glass shattered while driving

1. 1Fault

   • Liftgate, rear glass or door lock
   ↓→

2. 2Finding the cause

   • Rear Window Glass: broken
   ↓→

3. 3Correction

   • Rear Window Glass: replaced

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2017-08-15

Preliminary Information - Vibration Diagnosis Using Pico Oscilloscope

1. 1Fault

   • Vibration or shudder
   • Customer vibration complaints are among the most challenging to diagnose and repair accurately.
   ↓→

2. 2Finding the cause

   Steps to confirm (in the document’s order)

   1. Drive the vehicle to verify the condition and record a Pico data file of the concern.
   2. Review the Pico file and use it to help determine the root cause or component.
   ↓→

3. 3Correction

   Repair

   • Repair the vehicle using the Pico information together with any published information relevant to the vibration frequency observed.

   Caution

   • Without knowing the vibration frequency, repair attempts are just spinning wheels.
   • Component level vibrations such as blower motor, brake pulsation or shudder on turns do not require a Pico file; the requirement is for vehicle level vibration complaints.

Owner complaint2003 GMC YUKON ・ 2015-09-30

Right front fender rust and paint bubbling

1. 1Fault

   • Corrosion or rust
   ↓→

2. 2Finding the cause

   • Fender: corroded
   ↓→

3. 3CorrectionNot repaired

   THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED.

Manufacturer communication2003–2006 GMC YUKON DENALI ・ 2011-05-26

Frame Corrosion on Some Truck Models

1. 1Fault

   • Corrosion or rust
   ↓→

2. 2Finding the cause

   • Frame: corroded
   ↓→

3. 3Correction

   GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB

Owner complaint2003 GMC YUKON ・ 2016-06-07

Blower motor stopped working while driving

1. 1Fault

   • Air conditioning or heater
   ↓→

2. 2Finding the cause

   • Blower Motor: failed
   ↓→

3. 3CorrectionNot repaired

   THE VEHICLE WAS NOT REPAIRED.

Manufacturer communication2002–2005 GMC YUKON ・ 2005-11-04

Sunroof Jams When Closing

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   • Sunroof: failed
   ↓→

3. 3Correction

   SUNROOF JAMS WHEN CLOSING. *TT

Manufacturer communication2003–2006 GMC YUKON ・ 2005-11-01

Unwanted Operation of Rear Windows

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   UNWANTED OPERATION OF REAR WINDOWS. *TT

Manufacturer communication2003–2005 GMC YUKON DENALI ・ 2005-10-25

Service: Outside Rear View Mirror Inoperative

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   • Outside Rearview Mirror: repaired

Manufacturer communication2003–2006 GMC YUKON ・ 2005-09-20

Outside Rearview Mirror Vibration Service

1. 1Fault

   • Vibration or shudder
   ↓→

2. 2Finding the cause

   • Outside Rearview Mirror: defective
   ↓→

3. 3Correction

   SERVICE VME - OUTSIDE REARVIEW MIRROR VIBRATION. *TT

Manufacturer communication2000–2004 GMC YUKON ・ 2005-04-06

Front Door Power Window Motor Assemblies – Warranty Repair Information

1. 1Fault

   • Power window
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   BULLETIN 04-08-64-003, FRONT DOOR POWER WINDOW MOTOR ASSEMBLIES - WARRANTY REPAIR INFORMATION. *TT

Manufacturer communication2000–2003 GMC YUKON DENALI ・ 2012-02-06

Driver and Passenger Head Restraint Comfort for GM Vehicles

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE

Manufacturer communication2003–2006 GMC YUKON ・ 2006-01-06

Heated Seat Inoperative or Shut Off in 30 Seconds

1. 1Fault

   • Seat or seat heater
   • B2435
   • B2440
   • B3606
   • B1825
   ↓→

2. 2Finding the cause

   • Driver Seat Module: failed
   ↓→

3. 3Correction

   HEATED SEAT INOPERATIVE OR SHUT OFF IN 30 SECONDS. DIAGNOSTIC TROUBLE CODES B2435, B2440, B3606 AND/OR B1825 SET IN THE DRIVERS SEAT MODULE. *TT

Manufacturer communication2000–2005 GMC YUKON ・ 2005-11-30

Unwanted/Loose Seat Movement Communication

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   • Seat: loose or misadjusted
   ↓→

3. 3Correction

   UNWANTED/LOOSE SEAT MOVEMENT. *TT

Manufacturer communication2003–2005 GMC YUKON ・ 2005-11-05

Intermittent Heated Seats Inoperative, DTC B3941

1. 1Fault

   • Seat or seat heater
   • B3941
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   INTERMITTENT HEATED SEATS INOPERATIVE, DIAGNOSTIC TROUBLE CODE B3941 SET. *TT

Manufacturer communication2002–2006 GMC YUKON DENALI ・ 2018-06-04

Informational Bulletin Revision 05-08-48-001B

1. 1Fault

   • The bulletin gives retail and wholesale service personnel guidelines for using the windshield replacement labor operation.
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update Labor Operation.

Manufacturer communication2001–2006 GMC YUKON DENALI ・ 2018-05-21(1 earlier editions of this document folded here)

Liftgate Applique Replacement Procedure

1. 1Fault

   • Liftgate, rear glass or door lock
   • Condition 1: a dimpling or deformation is seen near an outer edge of the liftgate center applique.
   • Condition 2: paint damage on the liftgate at the lower outboard edges of the center applique.
   ↓→

2. 2Finding the cause

   Possible causes

   • The applique design might allow deformation or dimpling of its surface if the retaining nuts are overtightened.
   • The applique design together with the forming of the license plate pocket in the liftgate may let the lower outboard edges of the applique contact the liftgate.
   ↓→

3. 3Correction

   • Liftgate Applique: replaced

   Repair

   1. For 2011 or earlier vehicles, replace the liftgate center applique with the appropriate new service part from the table.
   2. To create clearance, add GM washer P/N 15911310 to the applique between the foam washer and the mounting boss at each of the four mounting stud locations.

   Part numbers printed in the document

   • 15911310Washer,Sun Roof HousingLook up at RockAuto (aftermarket candidates) ↗Search the web ↗

     Discontinued (no successor stated)as stated by GMPartsGiant (checked 2026-10-06) ↗

   The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

   Parts

   • P/N 15911310 is a 0.25 mm thick Mylar washer.
   • Applique 22777530 is for GMC non-hybrid without rear vision camera (-UVC).
   • Applique 22777531 is for GMC non-hybrid with rear vision camera (&UVC).

   Part numbers printed in the document

   • 15911310Washer,Sun Roof HousingLook up at RockAuto (aftermarket candidates) ↗Search the web ↗

     Discontinued (no successor stated)as stated by GMPartsGiant (checked 2026-10-06) ↗

   • 22777530Applique Assembly, Lift Gate Center *"No Color"Look up at RockAuto (aftermarket candidates) ↗Search the web ↗

     No successor stated(replaces 15915678)as stated by GMPartsGiant (checked 2026-10-06) ↗

   • 22777531Applique Assembly, Lift Gate Center *"No Color"Look up at RockAuto (aftermarket candidates) ↗Search the web ↗

     Replaced by: 23168610as stated by GMPartsGiant (checked 2026-10-06) ↗Look up at RockAuto (aftermarket candidates) ↗Search the web ↗

   The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

   Caution

   • The updated applique design went into production for the 2012 model year; the applique should not need replacement on a 2012 or newer vehicle unless Condition 1 is present.

Manufacturer communication2000–2005 GMC YUKON DENALI ・ 2018-05-21

Warranty Administration and Damage Classification Bulletin

1. 1Fault

   • The document gives warranty submission guidelines for outside rearview mirrors.
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   This warranty administration bulletin provides information on what should be considerd warranty damage or damage that was at fault of the cutomer and how to properly claim them on the warranty paperwork

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-05-21

Informational Bulletin on Latest PI and Service Bulletins

1. 1Fault

   • The document is a field product reminder list of issues by vehicle line under the heading Fix it Right the First Time; it is an index to other documents.
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.

Manufacturer communication2003–2006 GMC YUKON DENALI ・ 2008-12-12

Seat Position Sensor Circuits Notification

1. 1Fault

   • Warning light
   • B0084
   • B0085
   ↓→

2. 2Finding the cause

   • Seat Position Sensor: broken
   ↓→

3. 3Correction

   GMC: SIR MIL DTC B0084 AND/OR B0085. THIS CONCERN COULD BE CAUSED BY BROKEN SEAT POSITION SENSOR CIRCUITS UNDER THE DRIVER OR PASSENGER FRONT SEATS. OVER TIME, FROM REPEATED SEAT MOVEMENT, THE WIRING COULD BREAK. *PE

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2021-04-26

Underbody Component Corrosion Guidance

1. 1Fault

   • Corrosion or rust
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2021-04-26

Underbody Component Corrosion Information

1. 1Fault

   • Corrosion or rust
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

Manufacturer communication2000–2006 GMC YUKON ・ 2011-06-15

Front or rear door may not open from inside or outside handle

1. 1Fault

   Not stated

   ↓→

2. 2Finding the cause

   • Handle: design or manufacturing
   ↓→

3. 3Correction

   GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. ALL 2014 AND PRIOR GM PASSENGER CARS AND TRUCKS. *KB

Owner complaint2003 GMC YUKON ・ 2005-11-01

Hood flew up and hit windshield while driving at 70 MPH

1. 1Fault

   WHILE DRIVING DOWN THE INTERSTATE AT ABOUT 70 MPH (= 112.7 km/h) MY HOOD FLEW UP AND CRASHED INTO MY WINDSHIELD.

   ↓→

2. 2Finding the cause

   • Hood Rivet: broken
   ↓→

3. 3Correction

   Not stated

Owner complaint2003 GMC YUKON ・ 2008-06-18

Brake failure while approaching stop sign, and right front window inoperative

1. 1Fault

   • Reduced braking
   • Power window
   ↓→

2. 2Finding the cause

   Not stated

   ↓→

3. 3Correction

   • Power Window Motor: replaced
   • Window Regulator: replaced

Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2017-08-15(1 earlier editions of this document folded here)

Ultraviolet Protection and Tint Information for Glass

1. 1Fault

   • Owners may question the percentage of UV protection or tint offered by the windshield or side glass.
   ↓→

2. 2Finding the cause

   Steps to confirm (in the document’s order)

   1. Front side door glass reduces UV rays down to 35% or less.
   2. Rear window, door or quarter glass reduces UV rays down to 10% or less if equipped with Privacy Glass (RPO AJ1).
   3. Rear door glass, quarter windows and back windows can be either Solar glass (>/=70%) or Privacy glass, which has a nominal light transmittance of 20%.
   ↓→

3. 3Correction

   This Preliminary Information communication provides information to the technician about the percentage of Ultraviolet protection or tint offered by the windshield or side glass. Technician should be advised Windshield reduces Ultraviolet rays down to 4% or less. Front side door glass reduces Ultraviolet rays down to 35% or less. Windshields are SOLAR glass with a light transmittance of >/=70%. Front door glass are Solar glass with a light transmission of >/=70%. Rear door glass, quarter windows and back windows can use either Solar glass (>/=70%) or Privacy glass, which has a light transmittance of 20%.