Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

Common on this vehicle:Gauge or instrument faultNoiseWarning lightCorrosion or rustLeakReduced brakingAir conditioning or heaterVibration or shudder

Record by record

11 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it held for a while1
  • says it came back2

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (11)

Known issuesHVAC blower motor resistor module / connector overheating2

  1. Recall2003–2006 GMC YUKON ・ 2011-02-21

    HVAC Blower Motor Resistor Module Overheating

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      HVAC blower motor resistor module / connector overheating

      Repair

      1. Dealers install a new blower motor resistor and resistor module connector.
      2. Cut the wires back far enough to remove any melted insulation.

      Caution

      • The connector must be replaced even if it was replaced in an earlier repair.
    Read the sentences of the record
    Cause
    On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury. Correction: Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.

  2. Owner complaint2005 GMC YUKON ・ 2011-07-29

    Interior vehicle fire in dash

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      HVAC blower motor resistor module / connector overheating

      Repair

      1. Dealers install a new blower motor resistor and resistor module connector.
      2. Cut the wires back far enough to remove any melted insulation.

      Caution

      • The connector must be replaced even if it was replaced in an earlier repair.
    Read the sentences of the record
    Fault
    INTERIOR VEHICLE FIRE IN DASH. (1 more)
    Cause
    APPEARS SERVICE BULLETINS WERE ISSUED ABOUT REPLACING OVER HEATING RESISTORS FOR THE (HAVC) OPERATING SYSTEM.
    Consequence
    VEHICLE IS NOW TOTALLED.

Known issuesPositive battery cable contact with steering shaft universal joint (Denali) - Transport Canada 20010921

  1. Recall2001 GMC YUKON ・ 2001-04-12

    Positive battery cable fire risk recall

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Positive battery cable contact with steering shaft universal joint (Denali) - Transport Canada 2001092

      Repair

      1. Dealers inspect the cable routing and reroute if necessary.
      2. The cable is also inspected for wear and replaced if necessary.
    Read the sentences of the record
    Cause
    On certain Yukon Denali and Yukon XL Denali vehicles, the positive battery cable assembly that could come in contact with the steering shaft universal joint. This could eventually cause a wear through of the cable assembly convoluted conduit and cable insulation and result in intermittent electrical shorting. This could result in overheating and igniting of the cable insulation and conduit and a possible underhood fire. Correction: Dealers will inspect the positive battery cable for proper routing and reroute if necessary. Cable will also be inspected for wear of the conduit and cable insulation, and replaced if necessary.

Known issuesConversion equipment (not the vehicle as built): Southern Comfort running board courtesy lights overheating - recall 03V-0941

  1. Recall2000–2003 GMC YUKON ・ 2003-07-03

    Running board courtesy lights overheat or fire risk recall

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Cause
    CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
    Remedy
    DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
    Consequence
    THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

ELECTRICAL SYSTEM3

  1. Owner complaint2004 GMC YUKON DENALI ・ 2011-04-01

    Rear driver's side bucket seat caught fire

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    REAR BUCKET SEAT (DRIVER'S SIDE) CAUGHT FIRE.
    Cause
    THUS, CAR SEAT HEATER SOME HOW TURNED ITSELF ON, REMAINED ON, OVERHEATED, AND CAUGHT SEAT CUSHION MATERIAL ON FIRE.
    Consequence
    FURTHER, FIRE WAS DISCOVERED BEFORE SPREADING, ENGULFING CAR AND ENDANGERING OTHERS IN THE BUSY SCHOOL PARKING LOT.

  2. Owner complaint2004 GMC YUKON ・ 2017-05-08

    Rear air conditioner stopped blowing air while in park

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE FAILURE WAS NOT REMEDIED.

    Read the sentences of the record
    Fault
    WHILE THE VEHICLE WAS IN PARK, THE REAR AIR CONDITIONER STOPPED BLOWING AIR.
    Remedy
    THE FAILURE WAS NOT REMEDIED.
    Inspection
    THE CONTACT, WHO WAS AN INDEPENDENT MECHANIC, DIAGNOSED THAT THE ELECTRICAL CONNECTION LOCATED BEHIND A PLASTIC PANEL IN THE HOOD LATCH WAS OVERHEATED BY THE ELECTRICAL WIRES.

  3. Owner complaint2006 GMC YUKON ・ 2014-03-31

    Rear liftgate and rear liftgate window will not unlock or open

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE REAR LIFTGATE WILL NOT UNLOCK OR OPEN & REAR LIFTGATE WINDOW WILL NOT UNLOCK OR OPEN.

FUEL SYSTEM, GASOLINE2

  1. Owner complaint2003 GMC YUKON ・ 2004-07-23

    Fuel pump replacement required when fuel level low

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Cause
    IT SEEMS THAT THE PUMP IS LOCATED IN THE GAS TANK AND THE PUMP DEPENDS ON THE TANK HAVING ENOUGH LIQUID TO KEEP THE ELECTRIC PUMP COOL.
    Remedy
    GM HAS HAD TO REPLACE THE FUEL PUMP TWICE SO FAR AND WILL HAVE TO EVERY TIME I RUN LOW ON GASOLINE.

  2. Owner complaint2003 GMC YUKON ・ 2004-10-17

    Engine stalling while driving with check engine and traction control lights on

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    DRIVING 60 MPH (= 96.6 km/h) ON A 20 MILE (= 32.2 km) BRIDGE, THE ENGINE FAILED (ENGINE LIGHT AND TRACTION CONTROL LIGHT WERE ON. (1 more)
    Remedy
    REPLACED HARNESS. (1 more)
    Inspection
    THEY FOUND 2 MORE BROKEN WIRES. (1 more)

AIR BAGS1

  1. Owner complaint2005 GMC YUKON DENALI ・ 2014-05-21

    Airbag light on and multiple electrical, mechanical and comfort issues since 2005

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    AIRBAG LIGHT CONTINUOUSLY ON - READS, SERVICE AIRBAG. (13 more)
    Inspection
    I HAVE TAKEN IT IN FOR SERVICE SEVERAL TIMES BUT MIRACULOUSLY THE GMC SERVICE CENTER SAYS THE LIGHT DOESN'T COME ON WHEN THEY HAVE IT.

EXTERIOR LIGHTING1

  1. Owner complaint2003 GMC YUKON ・ 2006-08-14

    Driver side daytime running lights kept burning out

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    DT*: THE CONTACT STATED THE VEHICLE'S DRIVER SIDE DAY TIME RUNNING LIGHTS KEPT BURNING OUT.