Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
Add conditions (optional: symptom, model year, system, warning display, trouble code, kind of record)

Common on this vehicle:Does not startNoiseWarning light

Record by record

3 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (3)

Known issues4L80-E / 4L85-E planetary gear whine in first and second gear1

  1. Manufacturer communication2000–2006 GMC YUKON XL ・ 2017-08-15

    Planetary Gear Whine Noise in First and Second Gear

    1. 1Fault

      • The 4L80E/4L85E automatic transmission may have a planetary gear whine noise in first and second gear, typically louder in first gear than in second.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      1. If the noise is judged abnormal and the transmission was built after 9-01-03, perform the Rear Unit End Play Check (SI Document ID # 52027).
      2. The correct end play is between 0.127-0.508 mm (0.005-0.020 in).

    3. 3Correction

      Repair

      1. If end play is out of specification, inspect and replace the output planetary gear set (661 - Output Carrier Assembly and 650 - Sun Gear) as necessary.
      2. Set the rear end play with the correct selective thrust washer (674), targeting between .010 and .015 in.
      3. If end play is within specification, replace the transmission assembly, referring to bulletin 02-07-30-029A before ordering it.

      Caution

      • This planetary gear whine can be characteristic of the 4L80E/4L85E; compare the vehicle with an identically built vehicle (same GVWR) before attempting any repairs.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 1999-2007 GMC Sierra and Yukon XL (among other listed GM trucks and vans) with the 4L80E (RPO MT1) or 4L85E (RPO MN8) transmission (note: the Yukon XL range runs to 2007).
    • Condition：The 4L80E/4L85E automatic transmission may have a planetary gear whine noise in first and second gear, typically louder in first gear than in second.
    • Caution：This planetary gear whine can be characteristic of the 4L80E/4L85E; compare the vehicle with an identically built vehicle (same GVWR) before attempting any repairs.
    • Confirm：If the noise is judged abnormal and the transmission was built after 9-01-03, perform the Rear Unit End Play Check (SI Document ID # 52027).
    • Confirm：The correct end play is between 0.127-0.508 mm (0.005-0.020 in).
    • Repair：If end play is out of specification, inspect and replace the output planetary gear set (661 - Output Carrier Assembly and 650 - Sun Gear) as necessary.
    • Repair：Set the rear end play with the correct selective thrust washer (674), targeting between .010 and .015 in.
    • Repair：If end play is within specification, replace the transmission assembly, referring to bulletin 02-07-30-029A before ordering it.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary Information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. Technician should compare the noise to a like vehicle. Technician will need to check the build date of the transmission, if it was built after 09/01/2003 and it is determined that a vehicle has an abnormal amount of noise, perform the rear unit end play check. Technician will replace the output planetary gear set if end play is out of specification. The transmission assembly will need to be replaced if the end play is with in specification.

POWER TRAIN2

  1. Manufacturer communication2004 GMC YUKON XL ・ 2004-05-14

    4L80E/4L85E Transmission Overdrive Gear Set Lubrication

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

      4L80E / 4L85E TRANSMISSION MAY HAVE A CONDITION IN WHICH THE TRANSMISSION OVERDRIVE GEAR SET MAY FAIL DUE TO INADEQUATE LUBRICATION AS A RESULT OF A TRANSMISSION CASTING CHANGE. CUSTOMER SATISFACTION PROGRAM BULLETIN. ALSO TO INCLUDE 2004 CHEVROLET AND GMC W3500, W4500, AND ISUZU NPR, NPR-HD. *TT

    Read the sentences of the record
    Remedy
    4L80E / 4L85E TRANSMISSION MAY HAVE A CONDITION IN WHICH THE TRANSMISSION OVERDRIVE GEAR SET MAY FAIL DUE TO INADEQUATE LUBRICATION AS A RESULT OF A TRANSMISSION CASTING CHANGE. CUSTOMER SATISFACTION PROGRAM BULLETIN. ALSO TO INCLUDE 2004 CHEVROLET AND GMC W3500, W4500, AND ISUZU NPR, NPR-HD. *TT

  2. Manufacturer communication2003 GMC YUKON XL ・ 2003-11-25

    4L80E/4L85E Transmission Range Switch Performance Communication

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      4L80E/4L85E MAY SET A DIAGNOSTIC TROUBLE CODE (DTC) P0706 (TRANSMISSION RANGE SWITCH PERFORMANCE) AND EXHIBIT A NO START CONDITION. *TT

    Read the sentences of the record
    Remedy
    4L80E/4L85E MAY SET A DIAGNOSTIC TROUBLE CODE (DTC) P0706 (TRANSMISSION RANGE SWITCH PERFORMANCE) AND EXHIBIT A NO START CONDITION. *TT